[1]梁金华,邓国栋,王伟斌,等.硝基胍喷雾干燥过程连续计量加料技术[J].爆破器材,2022,51(06):9-15，21.[doi:10.3969/j.issn.1001-8352.2022.06.002]
　LIANG Jinhua,DENG Guodong,WANG Weibin,et al.Continuous Metering and Feeding Technology in Nitroguanidine Spray Drying Process[J].EXPLOSIVE MATERIALS,2022,51(06):9-15，21.[doi:10.3969/j.issn.1001-8352.2022.06.002]
点击复制

硝基胍喷雾干燥过程连续计量加料技术()
分享到：

《爆破器材》[ISSN:1001-8352/CN:32-1163/TJ]

卷:
51
期数:
2022年06
页码:
9-15，21
栏目:
基础理论
出版日期:
2022-11-25

文章信息/Info

Title:
Continuous Metering and Feeding Technology in Nitroguanidine Spray Drying Process
文章编号:
5728
作者:
梁金华; 邓国栋; 王伟斌; 谢亮; 王照轩
南京理工大学国家特种超细粉体工程技术研究中心（江苏南京，210094）
Author(s):
LIANG Jinhua;  DENG Guodong;  WANG Weibin;  XIE Liang;  WANG Zhaoxuan
National Special Superfine Powder Engineering Research Center, Nanjing University of Science and Technology (Jiangsu Nanjing, 210094)
关键词:
硝基胍; 喷雾干燥; 浓度; 流量; 计量
Keywords:
nitroguanidine;  spray drying;  concentration;  flow;  measurement
分类号:
TJ55；TQ560.6
DOI:
10.3969/j.issn.1001-8352.2022.06.002
文献标志码:
A
摘要:
在硝基胍（NQ）喷雾干燥加料过程中，为实现连续、安全、均匀、稳定地计量加料，对NQ喷雾干燥加料系统开展在线浓度、流量与干量计量检测的试验研究。采集不同浓度下的NQ浆料与纯NQ光谱，对比不同预处理方法的优化效果，采用偏最小二乘法选择特征区域建立加料浓度模型，并对模型进行重复性验证。选择一阶导数加标准正态变量变换方法对原始光谱进行预处理，在6 857~6 426 cm-1和5 119~4 257 cm-1两个波段内建立NQ加料浓度的定量模型，校正和预测的决定系数（R2c、R2p）分别为0.992 7和0.987 0；校正和预测的均方根误差（RMSEC、RMSEP）分别为0.256和0.340；对建立的校正模型进行外部验证,其检测浓度平均偏差为0.21%。研究了不同管道压力对直管型质量流量计流量测量的影响，确定最佳的进料压力范围：当管道压力在0.40~0.45 MPa范围内，流量检测误差均小于0.50%，满足质量流量计的检测要求；且在0.40 MPa时，流量测量误差最小，为0.37%。研究了NQ喷雾干燥在线连续计量加料系统在不同浓度、不同工作时间下的计量精度，该系统在6组不同浓度、10个不同工作时间下的干量计量误差均不大于1.00%，表明该系统可稳定、可靠地实现NQ在线连续干量计量。
Abstract:
To ensure continuous, safe, uniform and stable metering and feeding of nitroguanidine (NQ) in the spray drying process, experimental study on online measurement of concentration, flow and dry volume of NQ spray drying feeding system was carried out. The spectra of NQ slurry and pure NQ with different concentrations were collected, and the optimization effect of different pretreatment methods was compared. Partial least square (PLS) was used to develop the feeding concentration model based on specific spectral intervals, and repeatability of the developed model was validated. First-derivative add standard normal variate transformation was selected to preprocess the raw spectra, and the wavebands over the ranges from 6 857 cm-1 to 6 426 cm-1 and 5 119 cm-1to 4 257 cm-1 were used to constrict the quantitative model of NQ feeding concentration. Determination coefficient of correction and prediction (R2c and R2p) of the developed model are 0.992 7 and 0.987 0, respectively. Root mean square error of corrected and predicted (RMSECand RMSEP) of the developed model are 0.256 and 0.340, respectively. The established calibration model was externally verified, and average deviation of the detected concentration was 0.21%. The influence of different pipe pressures on the flow test results of the straight pipe type mass flowmeter was studied, and the optimal range of feed pressure was determined. When the pipeline pressure is within 0.40-0.45 MPa, the flow measurement error is less than 0.50%, which meets the detection requirements of the mass flowmeter. At 0.40 MPa, the flow measurement error is the minimum, 0.37%. Measuring accuracy of NQ spray drying online continuous metering feeding system under different concentrations and working hours was studied. Dry metering error of this system under 6 groups of different concentrations and 10 different working hours is no more than 1.00%, which shows that the system can stably and reliably realize NQ online continuous dry metering.

参考文献/References:

［1］周诚, 陈智群, 黄新萍, 等. 硝基胍标准物质的制备及其均匀性和稳定性研究 ［J］. 化学分析计量, 2009, 18(5): 4-6.
ZHOU C, CHEN Z Q, HUANG X P, et al. Preparation of reference material of NQ and study of its homogeneity and stability ［J］. Chemichiometry, 2009,18 (5): 4-6.
［2］DAGLEY I J, KONY M, WALKER G. Properties and impact sensitiveness of cyclic nitramine explosives containing nitroguanidine groups ［J］. Journal of Energetic Materials, 1995, 13(1/2): 35-56.?
［3］魏学涛, 赵颖, 李乃勤, 等. 新型硝基胍发射药研究 ［J］. 火炸药学报, 2001(4): 34-35, 36.
WEI X T, ZHAO Y, LI N Q, et al. The study on a new kind of nitroguanidine propellant ［J］. Chinese Journal of Explsoives & Propellants, 2001 (4): 34-35, 36.
［4］GRASSI S, ALAMPRESE C. Advances in NIR spectroscopy applied to process analytical technology in food industries ［J］. Current Opinion in Food Science, 2018, 22: 17-21.
［5］YU H J, DU W L, LANG Z Q, et al. A novel integrated approach to characterization of petroleum naphtha properties from nearinfrared spectroscopy ［J］. IEEE Transactions on Instrumentation and Measurement, 2021, 70: 1-13.
［6］BEC K B, GRABSKA J, HUCK C W. NIR spectroscopy of natural medicines supported by novel instrumentation and methods for data analysis and interpretation［J］. Journal of Pharmaceutical and Biomedical Analysis, 2021, 193: 113686.
［7］CUNHA C L, TORRES A R, LUNA A S. Multivariate regression models obtained from near-infrared spectroscopy data for prediction of the physical properties of biodiesel and its blends ［J］. Fuel, 2020, 261: 116344.
［8］AL-HARRASI A, REHMAN N U, MABOOD F, et al. Application of NIRS coupled with PLS regression as a rapid, non-destructive alternative method for quantification of KBA in Boswellia sacra ［J］. Spectrochimica Acta Part A: Molecular and Biomolecular Spectroscopy, 2017, 184: 277-285.
［9］WANG J. Near infrared optical biosensor based on peptide functionalized single-walled carbon nanotubes hybrids for 2,4,6-trinitrotoluene (TNT) explosive detection ［J］. Analytical Biochemistry, 2018, 550: 49-53.
［10］SU P F, LIANG W H, ZHANG G, et al. Quantitative detection of components in polymerbonded explosives through near-infrared spectroscopy with partial least square regression［J］. ACS Omega, 2021, 6: 23163-23169.
［11］PAWLAS G, GARNETT R, STACK C. Fluid-structure interaction analysis of a Coriolis mass flowmeter ［C］//23rd Fluid Dynamics, Plasmadynamics, and Lasers Conference. Orlando,FL,U S: American Institute of Aeronautics and Astronautics, 1993.
［12］黄以细, 唐军, 林愉. 单直管型科氏质量流量计的力学模型研究［J］. 科技广场, 2007(3): 11-14.
HUANG Y X, TANG J, LIN Y. Study of mechanical model of linear tube coriolis mass flow meter ［J］. Science Mosaic, 2007 (3): 11-14.
［13］ZHANG G, WANG Y, WANG W, et al. Rapid online determination of feed concentration in nitroguanidine spray drying process by near infrared spectroscopy ［J］. Infrared Physics & Technology, 2020, 109: 103432.?
［14］XU L, ZHOU Y P, TANG L J, et al. Ensemble preprocessing of near-infrared (NIR) spectra for multivariate calibration［J］. Analytica Chimica Acta, 2008, 616(2): 138-143.
［15］HU R, ZHANG L X, YU Z Y, et al. Optimization of soluble solids content prediction models in ‘Hami’ melons by means of Vis-NIR spectroscopy and chemometric tools ［J］. Infrared Physics & Technology, 2019, 102: 102999.
［16］DHANOA M S, LISTER S J, SANDERSON R, et al. The link between multiplicative scatter correction (MSC) and standard normal variate (SNV) transformations of NIR spectra ［J］. Journal of Near Infrared Spectroscopy, 1994, 2(1): 43-47.
［17］ISAKSSON T, NAE S T. The effect of multiplicative scatter correction (MSC) and linearity improvement in NIR spectroscopy ［J］. Applied Spectroscopy, 1988, 42(7): 1273-1284.
［18］李栋, 宋方臻, 刘保双. 单直管型科里奥利质量流量计动力学分析 ［J］. 中国仪器仪表, 2014(10): 52-56.
LI D, SONG F Z, LIU B S. Dynamics analysis of single straight tube coriolis mass flowmeter ［J］. China Instrumentation, 2014 (10): 52-56.
［19］何那仁朝格图, 邓国栋, 鲁磊明,等. 改性双基推进剂制备中硝化甘油的连续加料与计量技术 ［J］. 爆破器材, 2017, 46(4): 59-64.
HE N R, DENG G D, LU L M, et al. Continuous feeding and measurement of nitroglycerin in preparation process of modified double-base propellant ［J］.Explosive Materials, 2017, 46 (4): 59-64.

相似文献/References:

[1]石先锐,闫光虎,贾永杰,等.RDX和NGU对叠氮硝胺发射药动态燃烧稳定性的影响[J].爆破器材,2020,49(05):14.[doi:doi:10.3969/j.issn.1001-8352.2020.05.003]
　SHI Xianrui,YAN Guanghu,JIA Yongjie,et al.Influence of RDX and NGU on the Dynamic Combustion Stability of Azidonitramine Gun Propellants[J].EXPLOSIVE MATERIALS,2020,49(06):14.[doi:doi:10.3969/j.issn.1001-8352.2020.05.003]
[2]赵林林,郭效德,黄珊珊,等.硝基胍连续喷雾干燥数值模拟研究[J].爆破器材,2021,50(05):21.[doi:10.3969/j.issn.1001-8352.2021.05.004]
　ZHAO Linlin,GUO Xiaode,HUANG Shanshan,et al.Numerical Simulation of Continuous Spray Drying of Nitroguanidine[J].EXPLOSIVE MATERIALS,2021,50(06):21.[doi:10.3969/j.issn.1001-8352.2021.05.004]

备注/Memo

备注/Memo:
收稿日期：2022-06-02
基金项目：国防火炸药科研专项项目
第一作者：梁金华（1997-），男，硕士研究生，主要从事复合含能材料的制备及性能研究。E-mail:771002208@qq.com
通信作者：邓国栋（1965-），男，副研究员，主要从事复合含能材料的制备及性能研究。E-mail:13505196092@163.com
更新日期/Last Update: 2022-11-18