[1]李秉擘,罗一鸣,王红星,等.DFTNAN/DNTF二元相图及低共熔物熔融动力学研究[J].爆破器材,2021,50(05):14-20.[doi:10.3969/j.issn.1001-8352.2021.05.003]
　LI Bingbo,LUO Yiming,WANG Hongxing,et al.Binary Phase Diagrams and Eutectic Melting Kinetics of DFTNAN/DNTF[J].EXPLOSIVE MATERIALS,2021,50(05):14-20.[doi:10.3969/j.issn.1001-8352.2021.05.003]
点击复制

DFTNAN/DNTF二元相图及低共熔物熔融动力学研究()
分享到：

《爆破器材》[ISSN:1001-8352/CN:32-1163/TJ]

卷:
50
期数:
2021年05
页码:
14-20
栏目:
基础理论
出版日期:
2021-10-05

文章信息/Info

Title:
Binary Phase Diagrams and Eutectic Melting Kinetics of DFTNAN/DNTF
文章编号:
5591
作者:
李秉擘; 罗一鸣; 王红星; 杨斐; 雷伟
西安近代化学研究所（陕西西安，710065）
Author(s):
LI Bingbo;  LUO Yiming;  WANG Hongxing;  YANG Fei;  LEI Wei
Xi’an Modern Chemistry Institute (Shaanxi Xi’an, 710065)
关键词:
3; 5-二氟-2; 4; 6三硝基苯甲醚（DFTNAN）;  3; 4-二硝基呋咱基氧化呋咱（DNTF）;  二元相图;  低共熔物;  熔融动力学
Keywords:
3; 5-difluoro-2; 4; 6-trinitrobenzaldehyde (DFTNAN);  3; 4-bis(3-nitrofurazan-4-yl) furoxan (DNTF);  binary phase diagrams;  eutectic;  melting kinetics
分类号:
TQ560.7；O64
DOI:
10.3969/j.issn.1001-8352.2021.05.003
文献标志码:
A
摘要:
通过测定3,5-二氟-2,4,6-三硝基苯甲醚（DFTNAN）/3,4-二硝基呋咱基氧化呋咱（DNTF）二元混合体系熔融过程的差示扫描量热（DSC）特征量数据,建立了T-X和H-X二元相图，并获得了该混合体系低共熔物的组成和熔点。然后，研究了低共熔物以及熔点为80 ℃时混合物的黏度、机械感度和理论爆炸性能。分析了不同的升温速率和添加剂对低共熔物熔融过程的影响，并通过Sˇatava-Sˇesták、Coats-Redfern和通用积分方程获得了低共熔物熔融过程的动力学参数Ea、A和最概然机理函数。结果表明，由T-X相图和H-X相图计算得到的DFTNAN/DNTF低共熔物的组成m(DFTNAN)∶m(DNTF)分别为62.94∶37.06和62.88∶37.12，低共熔温度为63.84 ℃。调节DFTNAN和DNTF的比例，可使混合体系既达到熔铸工艺要求的工艺温度（≥80 ℃），又能保持较高的能量水平和较低的感度。随着升温速率的提高，熔融反应起始温度和峰温发生相应的延后；添加HMX或RDX后，熔融起始温度发生较明显的后移；DFTNAN/DNTF低共熔物的熔融动力学参数Ea和lgA分别为32.95 kJ/mol和2.81，最概然机理函数为f(α)=(1-α)2/3。
Abstract:
T-Xand H-Xbinary phase diagrams were established according to differential scanning calorimetry (DSC) thermal analysis data of the melting process of DFTNAN/DNTF mixed system with different compositions. Composition and melting point of the eutectic of the mixed system were obtained. Viscosity, mechanical sensitivity and theoretical explosion properties of the eutectic and the mixture with melting point of 80 ℃ were investigated. Effects of different heating rates and additives on the melting process of eutectic were studied. Finally, dynamics parameters Ea and Aof eutectic melting process, and the most probable mechanism function were obtained by Sˇatava-Sˇesták, Coats-Redfern and general -ntegral-equations. Results show that m(DFTNAN)∶m(DNTF) eutectic calculated from T-Xand H-Xphase diagrams are 62.94∶37.06 and 62.88∶37.12, respectively. And the eutectic temperature is 63.84 ℃. By adjusting the ratio of composition, the mixing system can not only reach the process temperature (≥80 ℃) required by the casting process, but also maintain a high energy level and a low sensitivity. With the increase of heating rate, both initial temperature and peak temperature of the eutectic melting process delay correspondingly. After the addition of HMX or RDX, melting point of the eutectic moved back obviously. Melting kinetic parameters Ea and lgAof the eutectic are 32.95 kJ/mol and 2.81, and the most probable mechanism function is f(α)=(1-α)2/3.

参考文献/References:

［1］陈玲, 舒远杰, 徐瑞娟, 等. 含能低共熔物研究进展［J］. 含能材料, 2013, 21(1): 108-115.
CHEN L, SHU Y J, XU R J, et al. Review on energetic eutectic［J］. Chinese Journal of Energetic Materials, 2013, 21(1): 108-115.
［2］王亲会. 熔铸混合炸药用载体炸药评述［J］. 火炸药学报, 2011, 34(5): 25-28,42.
WANG Q H. Overview of carrier explosive for melt-cast composite explosive［J］. Chinese Journal of Explosives and Propellants, 2011, 34(5): 25-28,42.
［3］KAZAKOV A I, DASHKO D V, NABATOVA A V, et al. Thermochemical and energy characteristics of DNTF and DNFF［J］. Combustion Explosion, and Shock Waves, 2018, 54(2): 147-157.
［4］任晓宁, 王江宁, 阴翠梅, 等. 新型高能量密度材料DNTF的热分解特性［J］. 火炸药学报, 2006, 29(2): 33-36, 40.
REN X N, WANG J N, YIN C M, et al. Thermal decomposition characteristics of a novel high energy density material DNTF［J］. Chinese Journal of Explosives and Propellants, 2006, 29(2): 33-36, 40.
［5］赵凤起, 陈沛, 罗阳, 等. 含3,4-二硝基呋咱基氧化呋咱（DNTF）的改性双基推进剂［J］. 推进技术, 2004, 25(6): 570-572,576.
ZHAO F Q, CHEN P, LUO Y, et al. Study on the composite modified double base propellant containing 3,4-dinitrofurazanfuroxan (DNTF)［J］. Journal of Propulsion Technology, 2004, 25(6): 570-572,576.
［6］DUDDU R, HOARE J, SANCHEZ P, et al. Synthesis of nitro, dinitro, and polynitroalkylamino derivatives of trifurazanoxide［J］. Journal of Heterocyclic Chemistry, 2017, 54(6): 3087-3092.
［7］LI X, WANG B L, LIN Q H, et al. Compatibility study of DNTF with some insensitive energetic materials and inert materials［J］. Journal of Energetic Materials, 2016, 34(4): 409-415.
［8］田军, 王宝成, 桑军锋, 等. DNTF-CMDB 推进剂性能的实验研究［J］. 火炸药学报, 2015, 38(4): 76-79.
TIAN J, WANG B C, SANG J F, et al. Experimental research on the properties of CMDB propellant containing DNTF［J］. Chinese Journal of Explosives and Propellants, 2015, 38(4): 76-79.
［9］王浩, 王亲会, 黄文斌, 等. DNAN降低DNTF冲击波感度研究［J］. 含能材料, 2010, 18(4): 435-438.
WANG H, WANG Q H, HUANG W B, et al. Shock sensitivity of DNTF reduced by using DNAN［J］. Chinese Journal of Energetic Materials, 2010, 18(4): 435-438.
［10］周文静, 张皋, 刘子如. DNTF、TNT和DNTF-TNT低共熔物在RDX中的结晶动力学研究［J］. 含能材料, 2008, 16(3): 267-271.
ZHOU W J, ZHANG G, LIU Z R. Kinetics of non-isothermal crystallizations of DNTF, TNT and TNDF-TNT eutectic system crystallization in RDX［J］. Chinese Journal of Energetic Materials, 2008, 16(3): 267-271.
［11］刘艳, 刘子如, 阴翠梅. 1,3,3-三硝基氮杂环丁烷（TNAZ）的二元相图和低共熔物［J］. 含能材料, 2004,12(增刊): 227-230.
LIU Y, LIU Z R, YIN C M. The phase diagram and eutectic of binary system for 1,3,3-trinitroazetidine（TNAZ）with some energetic materials［J］. Chinese Journal of Energetic Materials, 2004,12(Suppl.): 227-230.
［12］高杰, 王浩, 罗一鸣, 等. DNAN/DNTF混合体系的二元相图及其机械感度研究［J］. 火炸药学报, 2020, 43(2): 213-218, 224.
GAO J, WANG H, LUO Y M, et al. Study on binary phase diagram of DNAN/DNTF mixed system and its mechanical sensitivity［J］. Chinese Journal of Explosives and Propellants, 2020, 43(2): 213-218, 224.
［13］陈玲, 徐瑞娟, 徐涛, 等. 甲基硝基胍基低共熔物的熔融动力学研究［J］. 含能材料, 2013, 21(6): 781-785.
CHEN L, XU R J, XU T, et al. Melting kinetics of eutectic based on methyl-nitroguanidine［J］. Chinese Journal of Energetic Materials, 2013, 21(6): 781-785.
［14］任晓宁, 衡淑云, 邵颖惠, 等. DNTF／PETN体系的二元相图及低共熔物［J］. 含能材料, 2009, 17(4): 455-458.
REN X N, HENG S Y, SHAO Y H, et al. The binary phase diagram and eutectic system for DNTF／PETN［J］. Chinese Journal of Energetic Materials, 2009, 17(4): 455-458.
［15］刘子如. 含能材料热分析［M］. 北京: 国防工业出版社，2009: 388-394.
LIU Z R. Thermal analyses for energetic materials［M］. Beijing: National Defense Industry Press, 2009: 388-394.
［16］周文静, 覃光明, 张皋, 等．DNTF的非等温结晶研究：I．在HMX中的结晶动力学［J］. 含能材料, 2007, 15(6): 629-632．
ZHOU W J, QIN G M, ZHANG G, et al. Non-isothermal crystallization of DNTF: I. crystallization kinetics in HMX［J］. Chinese Journal of Energetic Materials, 2007, 15(6): 629-632．
［17］周文静, 刘子如, 张皋等. DNTF的非等温结晶研究(Ⅱ)：在RDX中的结晶动力学［J］. 含能材料, 2008, 16(1): 16-18,22．
ZHOU W J, LIU Z R, ZHANG G, et al. Behavior of non-isothermal crystallization of DNTF(Ⅱ): crystallization kinetics in RDX［J］. Chinese Journal of Energetic Materials, 2008, 16(1): 16-18,22.
［18］刘翔. 生物质混煤燃烧及灰熔融动力学特性的实验研究［D］. 北京: 北京交通大学, 2012.
LIU X. Study on co-combustion kinetics and ash fusion kinetics of biomass with bituminous coal［D］. Beijing: Beijing Jiaotong University, 2012.
［19］王雷. 城市垃圾焚烧飞灰熔融处理实验研究［D］. 杭州：浙江大学, 2003.
WANG L. Experimental study on the melting of municipal solid waste incineration fly ash［D］. Hangzhou: Zhejiang University, 2003.
［20］胡荣祖, 高胜利, 赵凤起, 等. 热分析动力学［M］.2版.北京: 科学出版社，2008: 151-155.

相似文献/References:

[1]祝洁①,许登②,王鹏程②.2,6-双(二硝基亚甲基)-1,3,4,5,7,8-六硝基十二氢二咪唑［4,5-b:4′,5′-e］吡嗪分子结构及性能的理论计算[J].爆破器材,2018,47(03):1.[doi:10.3969/j.issn.1001-8352.2018.03.001]
　ZHU Jie,XU Deng,WANG Pengcheng.Computational Study on the Chemical Structure and Explosive Properties of 2,6-Bis(dinitromethylidene)-1,3,4,5,7,8-hexanitrododecahydrodiimidazo-［4,5-b:4′,5′-e］pyrazine[J].EXPLOSIVE MATERIALS,2018,47(05):1.[doi:10.3969/j.issn.1001-8352.2018.03.001]
[2]汪营磊,高福磊,丁峰,等.3,4-二硝基吡唑合成放大工艺研究[J].爆破器材,2018,47(05):35.[doi:10.3969/j.issn.1001-8352.2018.05.006]
　WANG Yinglei,GAO Fulei,DING Feng,et al.Study on the Up-sizing Synthesis Technology of 3, 4-Dinitropyrazole[J].EXPLOSIVE MATERIALS,2018,47(05):35.[doi:10.3969/j.issn.1001-8352.2018.05.006]
[3]靳永勇①,韩坤祥②,陈朋朋③,等.N2O5/HNO3硝化合成1,2,3,4-丁四醇四硝酸酯[J].爆破器材,2019,48(01):27.[doi:10.3969/j.issn.1001-8352.2019.01.005]
　JIN Yongyong,HAN Kunxiang,CHEN Pengpeng,et al.Synthesis of Erythritol Tetranitrate by N2O5/HNO3 System[J].EXPLOSIVE MATERIALS,2019,48(05):27.[doi:10.3969/j.issn.1001-8352.2019.01.005]
[4]邹政平,赵凤起,张明,等.DNTF应用技术研究进展[J].爆破器材,2019,48(04):11.[doi:10.3969/j.issn.1001-8352.2019.04.002]
　ZOU Zhengping,ZHAO Fengqi,ZHANG Ming,et al.Research Progress of 3,4-Dinitrofurazanfuroxan Performances and Its Applications[J].EXPLOSIVE MATERIALS,2019,48(05):11.[doi:10.3969/j.issn.1001-8352.2019.04.002]
[5]雷伟,罗一鸣,张蒙蒙,等.3，4-二硝基吡唑(DNP)的研究进展[J].爆破器材,2020,49(05):1.[doi:doi:10.3969/j.issn.1001-8352.2020.05.002]
　LEI Wei,LUO Yiming,ZHANG Mengmeng,et al.Research Progress of 3,4-Dinitropyrazole (DNP)[J].EXPLOSIVE MATERIALS,2020,49(05):1.[doi:doi:10.3969/j.issn.1001-8352.2020.05.002]

备注/Memo

备注/Memo:
收稿日期：2021-03-20
基金项目：国防重大专项
第一作者：李秉擘（1982-），男，硕士，工程师，主要从事熔铸炸药配方及工艺研究。E-mail：lbb500@sina.com
更新日期/Last Update: 2021-10-04