[1]卫欣欣①②,胡双启①,董国强②,等.水雾对黏塑性炸药PBXN-5燃烧的抑制作用研究[J].爆破器材,2021,50(06):14-20.[doi:10.3969/j.issn.1001-8352.2021.06.003]
　WEI Xinxin,HU Shuangqi,DONG Guoqiang,et al.Research on Combustion Inhibition of Water Mist on PBXN-5[J].EXPLOSIVE MATERIALS,2021,50(06):14-20.[doi:10.3969/j.issn.1001-8352.2021.06.003]
点击复制

水雾对黏塑性炸药PBXN-5燃烧的抑制作用研究()
分享到：

《爆破器材》[ISSN:1001-8352/CN:32-1163/TJ]

卷:
50
期数:
2021年06
页码:
14-20
栏目:
基础理论
出版日期:
2021-11-26

文章信息/Info

Title:
Research on Combustion Inhibition of Water Mist on PBXN-5
文章编号:
5611
作者:
卫欣欣①②; 胡双启①; 董国强②; 胡立双①; 崔超①; 冯永安①; 要雅靖①
①中北大学环境与安全工程学院（山西太原，030051）
②兵器工业卫生研究所（陕西西安，710065）
Author(s):
WEI Xinxin①②;  HU Shuangqi①;  DONG Guoqiang②;  HU Lishuang①;  CUI Chao①;  FENG Yongan①;  YAO Yajing①
①School of Environment and Safety Engineering,North University of China (Shanxi Taiyuan, 030051)
②Institute of Industrial Hygiene of Ordnance Industry (Shaanxi Xi‘an, 710065)
关键词:
堆积状态; PBXN5; 燃烧抑制; 水雾; 灭火
Keywords:
accumulation state;  PBXN-5;  combustion inhibition;  water mist;  fire extinction
分类号:
TQ560.7
DOI:
10.3969/j.issn.1001-8352.2021.06.003
文献标志码:
A
摘要:
为研究水雾对自由堆积状态黏塑性炸药PBXN-5粉末燃烧的抑制作用，搭建了开放式燃烧试验装置，选用了粒度范围D98=425 μm的PBXN-5粉末，分别对无水雾、喷水压力为0.5 MPa和2.0 MPa 3种条件下堆积状态PBXN-5的燃烧过程进行了试验，获得了火焰传播过程及火焰温度随时间的分布曲线。结果表明：在水雾喷水压力为0.5 MPa 和2.0 MPa时，堆积状态PBXN-5的燃烧持续时间分别是自由燃烧时的32.6%和31.8%，说明水雾对于PBXN-5燃烧有很好的抑制作用；灭火时间分别为377.011 ms和115.004 ms，而且2.0 MPa时火焰的最高下降速率较0.5 MPa时有所增加，表明对于堆积状态PBXN-5火焰抑制效果来说，雾动量的影响较雾滴粒径强。
Abstract:
An open combustion test device was set up to study the combustion inhibition of water mist on the free accumulation state PBXN-5 powder. PBXN-5 powder with particle size ofD98=425 μm was selected to test the combustion processes of accumulated state PBXN-5 under three conditions of no water mist, water mist with spray pressure of 0.5 MPa and 2.0 MPa, respectively. Flame propagation process and distribution curve of flame temperature with time were obtained. Results show that, when the water spray pressures are 0.5 MPa and 2.0 MPa, combustion duration of PBXN-5 in stacked state is 32.6% and 31.8% of that in free combustion respectively, indicating that water mist has a good inhibitory effect on PBXN-5 combustion. When the spray pressure is 0.5 MPa and 2.0 MPa, the extinguishing time is 377.011 ms and 115.004 ms, respectively. And the maximum flame decline rate at 2.0 MPa increases compared with that at 0.5 MPa, which indicates that the fog momentum has a stronger effect on the flame suppression of PBXN-5 in stacked state than the particle size of fog drops.

参考文献/References:

［1］廖亚立，傅孝忠，吴雪艳.火炸药事故应急管理现状研究 ［J］. 价值工程,2012,31(16):304.
LIAO Y L,FU X Z,WU X Y. Status quo of explosive accident emergency management ［J］. Value Engineering,2012,31(16):304.
［2］刘志超. 直通式旋流细水雾喷嘴雾化理论分析及灭火实验研究 ［D］.成都：西南交通大学,2007.
LIU Z C.Theoretical analysis of atomization and fire extinguishing experimental research on swirling water mist nozzles with straight ［D］.Chengdu:Southwest Jiaotong University,2007.
［3］刘秀云，吴超，陈玉琼. 细水雾灭火影响因素研究进展 ［J］. 消防科学与技术,2010,29(4):269-272.
LIU X Y,WU C,CHEN Y Q. Progress in the research of factors affecting the extinguishing property of water mist ［J］. Fire Science and Technology,2010, 29(4):269-272.
［4］刘全义，伊笑莹，吕志豪，等. 细水雾灭火有效性研究进展 ［J］. 科学技术与工程,2019,19(22):11-19.
LIU Q Y,YI X Y, Lǔ Z H, et al. Progress on water mist fire suppression effectiveness ［J］. Science Technology and Engineering, 2019, 19(22):11-19.
［5］JONES A，THOMAS G O. The action of water sprays on fires and explosions: A review of experimental work［J］.Transactions of the Institution of Chemical Engineers，1993，71(B1): 41-49.
［6］LIU Z G，KIM A K. A review of water mist fire suppression systems:fundamental studies ［J］.Journal of Fire Protection Engineering，1999，10(3): 32-50.
［7］XU H L，WANG X S，LI Y，et al. Experimental investigation of methane/coal dust explosion under influence of obstacles and ultrafine water mist［J］.Journal of Loss Prevention in the Process Industries，2017,49(B)：929-937.
［8］GAN B, LI B, JIANG H P, et al. Suppression of polymethyl methacrylate dust explosion by ultrafine water mist/additives［J］. Journal of Hazardous Materials，2018，351：346-355.
［9］WILLAUER H D,ANANTH R, FARLEY J P, et al. Mitigation of TNT and Destex explosion effects using water mist［J］. Journal of Hazardous Materials，2009，165(1/2/3)：1068-1073.
［10］袁凤英，刘小平. 氟橡胶含量的分析：关于PBXN-5传爆药制造工艺的成份分析 ［J］. 太原机械学院学报,1990,11(3):82-85.
YUAN F Y, LIU X P. The analysis of the viton content during the manufacturing process of the booster explosive PBXN-5 ［J］. Journal of Taiyuan Institute of Machinery, 1990,11(3):82-85.
［11］徐振相，秦志春，王成，等. 国内外传爆药的发展概况［J］. 火工品,1995(3):29-32.
XU Z X,QIN Z C,WANG C, et al. Development Situation of booster ［J］. Initiators & Pyrotechnics,1995(3):29-32.
［12］王金英，张景林. PBXN-5传爆药安全可靠性试验方法研究 ［J］. 中国安全科学学报,2010,20(1):72-76.
WANG J Y, ZHANG J L. Experimental study on the reliability and safety of PBXN-5 booster ［J］. China Safety Science Journal,2010,20(1):72-76.
［13］吴龙标，张洪江，李力. 细水雾灭火技术与应用［M］.南昌：江西科学技术出版社,2014.
［14］丛北华,翁韬,王喜世,等.细水雾抑制熄灭固体火的机理［J］.燃烧科学与技术,2007，13(1):40-44.
CONG B H,WENG T,WANG X S, et al. Fire suppression mechanisms of solid fires with water mist ［J］. Journal of Combustion Science and Technology,2007,13(1):40-44.
［15］陈庆,魏旭,陈光,等.不同压力下细水雾雾场特征参量模拟研究［J］.消防科学与技术,2020,39(6):803-806.
CHEN Q,WEI X,CHEN G, et al. Research on the atomization characteristics of fine water under different pressure ［J］. Fire Science and Technology,2020, 39(6):803-806.
［16］LIAO G X，HUANG X，CONG B H，et al. Progress in water mist fire suppression technology［J］. Journal of University of Science and Technology of China，2006，36(1)：9-19.
廖光煊，黄鑫，丛北华,等.细水雾灭火技术研究进展［J］.中国科学技术大学学报，2006，36(1)：9-19.

备注/Memo

备注/Memo:
收稿日期：2021-05-27
第一作者：卫欣欣（1996-），女，硕士研究生，主要从事防火防爆的研究。E-mail：842082529@qq.com
通信作者：胡立双（1985-），男，副教授，硕导，主要从事防火防爆的研究。E-mail：hlsly1314@163.com
更新日期/Last Update: 2021-11-19