[1]段红珍①②,钱华①③,万方①,等.导爆管的示踪剂溯源方法研究[J].爆破器材,2012,41(04):12-15.
　DUAN Hongzhen,QIAN Hua,WAN Fang,et al.Tracing Source Technology for Shockconducting Tube[J].EXPLOSIVE MATERIALS,2012,41(04):12-15.
点击复制

导爆管的示踪剂溯源方法研究()
分享到：

《爆破器材》[ISSN:1001-8352/CN:32-1163/TJ]

卷:
41
期数:
2012年04
页码:
12-15
栏目:
基础理论
出版日期:
2012-08-20

文章信息/Info

Title:
Tracing Source Technology for Shockconducting Tube
文章编号:
4461
作者:
段红珍①② ; 钱华①③; 万方①; 潘峰①③; 杨祖一④; 刘大斌①
 ①南京理工大学化工学院（江苏南京，210094）
 ②中北大学理学院化学系（山西太原，030051）
 ③国家民用爆破器材质量监督检验中心（江苏南京，210094）
 ④中国爆破器材行业协会（北京，100089）
Author(s):
DUAN Hongzhen①②; QIAN Hua①③; WAN Fang①; PAN Feng①③; YANG Zuyi④; LIU Dabin①
① School of Chemical Engineering，Nanjing University of Science and Technology (Jiangsu Nanjing，210094)
② Department of Chemistry, School of Science, North University of China (Shanxi Taiyuan, 030051)
③ National Quality Supervision and Inspection Center for Industrial Explosive Materials of China (Jiangsu Nanjing，210094) 
④ China Explosive Materials Trade Association (Beijing，100089)
关键词:
塑料导爆管; 示踪剂; 溯源特性; 电感耦合等离子发射光谱仪（ICP）
Keywords:
plastic shock-conducting tube;  tracer;  trace source characteristic;  Inductively Coupled Plasma
分类号:
TJ45+7
文献标志码:
A
摘要:
为了能使导爆管具有良好的可溯源特性，研究了示踪剂在导爆管中的添加方法以及检测方法，通过改变示踪剂的组分及其添加量，得到含有不同种类示踪剂的导爆管，利用电感耦合等离子发射光谱对爆前和爆后样品中的示踪剂配比及含量进行研究，探讨了导爆管的装药均匀性、导爆管取样长度、导爆管取样位置对爆后测试结果的影响。结果表明，导爆管的装药均匀性及取样位置对示踪效果影响较小，长度为10cm的导爆管取样量可以保证检测结果的有效性，半定量设计配比法可以有效地解决导爆管的溯源问题。
Abstract:
Aiming at effectively tracing the source of shock-conducting tube, tracer adding method and the detection method were studied in this paper. Shock-conducting tubes with different tracers and dosages were prepared by changing tracer component and its mass. The prepared shock-conducting tubes before detonation and after detonation were tested by Inductively Coupled Plasma method . The influence of doping uniformity, shock-conducting tube sampling length and sampling location on the test result after detonation was discussed. The results illustrate that the influences of doping uniformity and sampling location are insignificant. In addition, sampling shock-conducting tube of 10 cm can ensure the validity of the test results and the half quantitative design method could effectively solve the problem of the shock-conducting tube traceability. 

参考文献/References:

［1］Tian F.F., Yu J., Hu J.H., et al．Determination of Emulsion Explosives with Span80 as Emulsifier by Gas Chromatographymass Spectrometry［J］．J.Chromatogr. A, 2011，1218 (22)：3521-3528．
［2］杨祖一，闫正斌，亓希国．爆破器材流向信息标识和识读方式研究［J］．爆破器材，2004，33(增刊)：109-114．
［3］李月明，陈波.工业雷管编码技术之比较［J］．爆破器材，2004，33(增刊)：114-117．
［4］段红珍，钱华，万方，等．示踪剂的添加对导爆管传爆性能的影响［J］．爆破器材，2012，41（2）：5-7.
［5］何中其，彭金华，刘大斌，等．导爆管传爆性能设计与参数分析［J］．爆破器材，2010，39(3)：1-3．
［6］荆术祥，钱华，刘大斌，等．装药量对塑料导爆管传爆性能的影响［J］．爆破器材，2010，39(5)：4-6．
［7］刘大斌．塑料导爆管的起爆、传爆及输出性能研究［D］．南京：南京理工大学，2002．
［8］杨耀华．浅析影响导爆管传爆及点火性能的因素［J］．火工品，2003（2）：44-46．
［9］曹刚．大型仪器在水处理吸附方面的应用［J］．化学工程与装备， 2011（10）：178-179.

相似文献/References:

[1]郑思友,翟廷海.工业雷管可靠起爆塑料导爆管试验研究[J].爆破器材,2010,39(02):29.
　ZHENG Siyou,Experimental Study on Detonating Plastic Nonel Tube Reliably by Industrial Detonator[J].EXPLOSIVE MATERIALS,2010,39(04):29.
[2]徐平,唐书升.塑料导爆管生产安全性探讨[J].爆破器材,2010,39(03):25.
　XU Ping,Tang Shusheng.Discussion on the Safety in Production of Nonel Tube[J].EXPLOSIVE MATERIALS,2010,39(04):25.
[3]荆术祥,钱华,刘大斌,等.装药量对塑料导爆管传爆性能的影响[J].爆破器材,2010,39(05):4.
　JING Shuxiang,QIAN Hua,LIU Dabin,et al.Influence of the Explosive Charge on Explosion Propagation of the Nonel Tube[J].EXPLOSIVE MATERIALS,2010,39(04):4.
[4]侯建华①,鲍国钢②,朱长江②.导爆管长度对导爆管雷管延期时间的影响[J].爆破器材,2014,43(05):35.[doi:10.3969/j.issn.1001-8352.2014.05.008]
　HOU Jianhua,BAO Guogang,ZHU Changjiang.Effect of the Length of Detonating Tube on the Delay Time of Nonel Detonator[J].EXPLOSIVE MATERIALS,2014,43(04):35.[doi:10.3969/j.issn.1001-8352.2014.05.008]
[5]吕莎莎①,王海亮①,王万仁②,等.基于高速摄像的导爆管传爆过程研究[J].爆破器材,2020,49(01):40.[doi:10.3969/j.issn.1001-8352.2020.01.008]
　L Shasha,WANG Hailiang,WANG Wanren,et al.Research on Detonating Process of Nonel Tube by High Speed Camera[J].EXPLOSIVE MATERIALS,2020,49(04):40.[doi:10.3969/j.issn.1001-8352.2020.01.008]
[6]段红珍①②,钱华①,万方①,等.示踪剂的添加对导爆管传爆性能的影响[J].爆破器材,2012,41(02):5.
　DUAN Hongzhen,QIAN Hua,WAN Fang,et al.Influence of the Indicator on Detonation Transmission Performance of the Shockconducting Tube[J].EXPLOSIVE MATERIALS,2012,41(04):5.

备注/Memo

备注/Memo:
收稿日期：2012-02-29
基金项目：公安部重点研究项目（2009ZDYJNJLG032）
作者简介：段红珍（1971~），女，博士，副教授，主要从事纳米材料制备及性能测试方面的研究。
通讯作者：刘大斌（1963~），男，教授，博导，主要从事含能材料的制备与应用研究。
更新日期/Last Update: 2012-08-30