[1]林继凯①,孙梦迪②,刘增辉②,等.中部空气间隔不同比例装药对炮孔孔壁受力及碎石块度的影响[J].爆破器材,2023,52(06):55-64.[doi:10.3969/j.issn.1001-8352.2023.06.009]
　LIN Jikai,SUN Mengdi,LIU Zenghui,et al.Influence of Charge with Different Proportions under the Condition of Middle Air Separation on the Stress on the Borehole Wall and the Rock Fragmentation[J].EXPLOSIVE MATERIALS,2023,52(06):55-64.[doi:10.3969/j.issn.1001-8352.2023.06.009]
点击复制

中部空气间隔不同比例装药对炮孔孔壁受力及碎石块度的影响()
分享到：

《爆破器材》[ISSN:1001-8352/CN:32-1163/TJ]

卷:
52
期数:
2023年06
页码:
55-64
栏目:
爆破技术
出版日期:
2023-12-05

文章信息/Info

Title:
Influence of Charge with Different Proportions under the Condition of Middle Air Separation on the Stress on the Borehole Wall and the Rock Fragmentation
文章编号:
5808
作者:
林继凯①; 孙梦迪②; 刘增辉②; 赵高明②; 王世伟②; 王凡繁③
①山西长治经坊煤业有限公司（山西长治，047100）
②安徽理工大学矿业工程学院（安徽淮南，232001）
③芜湖海螺水泥有限公司（安徽芜湖，241200）
Author(s):
LIN Jikai①;  SUN Mengdi②;  LIU Zenghui②;  ZHAO Gaoming②;  WANG Shiwei②;  WANG Fanfan③
①Shanxi Changzhi Jingfang Coal Industry Co., Ltd. (Shanxi Changzhi, 047100)
②School of Mining Engineering, Anhui University of Science and Technology (Anhui Huainan, 232001)
③Wuhu Conch Cement Co., Ltd. (Anhui Wuhu, 241200)
关键词:
露天爆破; 空气间隔装药; 孔壁冲击压力; 碎石块度
Keywords:
open-bit blasting;  charge with air separation;  shock pressure on borehole wall;  rock fragmentation
分类号:
TD235
DOI:
10.3969/j.issn.1001-8352.2023.06.009
文献标志码:
A
摘要:
为分析装药中部不同空气间隔位置对炮孔孔壁受力的影响，以Starfield迭加法为基础，得出中部空气间隔装药爆破时整段孔壁上的冲击压力计算公式。在ANSYS-DYNA中建立多组不同中部空气间隔位置的计算模型，对孔壁及周围岩体的受力和损伤度进行分析。最后，进行现场爆破实验，使用WipFrag软件对碎石块度分布的变化规律进行分析。结果表明：中部空气间隔装药爆破时，孔壁压力整体呈现两端大、中间小的分布特征，装药段孔壁受到的冲击压力达到最大，冲击波以8字型向炮孔周围传播。当空气间隔位置在装药段中点时，上、下段药柱周围岩体受力大致相等，碎石块度相对均匀。因此，垂直台阶进行露天爆破开采时，为降低大块和粉料的产生率，空气柱上、下段可进行等比例装药，倾斜边坡可以适当向上调整空气间隔位置。
Abstract:
In order to analyze the influence of different air column positions in the middle of the charge on the stress on borehole wall, based on the Starfield superposition method, the calculation formula for the impact pressure on the entire borehole wall during the middle air interval charging blasting was obtained. Multiple calculation models for different central air column positions were established using ANSYS-DYNA, and the stress and damage degree of the borehole wall and surrounding rock mass were analyzed. Finally, on-site blasting experiments were conducted, and the distribution and variation of the fragmentation were analyzed using WipFrag software. The results show that, during the middle air interval charging blasting, the overall pressure on borehole wall shows a large distribution at both ends and a small distribution in the middle. The impact pressure on the borehole wall in the charging section reaches its maximum, and the shock wave propagates around the hole in an 8-shaped pattern. When the air column position is at the midpoint of the charging section, the stress on the rock mass around the upper and lower sections of the charging column is roughly equal, and the block size is relatively uniform. Therefore, when the open-pit blasting mining is conducted on vertical benches, in order to reduce the production rate of large blocks and powder, the upper and lower sections of the air column can be charged in equal proportions, and the air column position can be appropriately adjusted upwards on inclined slopes.

参考文献/References:

［1］尹岳降, 夏文俊, 卢文波, 等. 灰岩矿爆破开采岩粉成因及其控制研究［J］. 工程爆破, 2021, 27(6): 44-51.
YING Y J, XIA W J, LU W B, et al. Study on genesis and control of rock powder of limestone mine during rock blasting ［J］. Engineering Blasting, 2021, 27(6): 44-51.
［2］康永全, 薛里, 孙崔源, 等. 间隔不耦合装药结构形式及特点分析［J］. 工程爆破, 2020, 26(5): 62-67.
KANG Y Q, XUE L, SUN C Y, et al. Structural form and characteristic analysis of charge structure with deck decoupling ［J］. Engineering Blasting, 2020, 26(5): 62-67.
［3］朱红兵, 卢文波, 吴亮. 空气间隔装药爆破机理研究［J］. 岩土力学, 2007, 28(5): 986-990.
ZHU H B, LU W B, WU L. Research on mechanism of airdecking technique in bench blasting ［J］. Rock and Soil Mechanics, 2007, 28(5): 986-990.
［4］楼晓明, 王振昌, 陈必港, 等. 空气间隔装药孔壁初始冲击压力分析［J］. 煤炭学报, 2017, 42(11): 2875-2884.
LOU X M, WANG Z C, CHEN B G, et al. Initial shock pressure analysis for hole wall with air-decked charge ［J］. Journal of China Coal Society, 2017, 42(11): 2875-2884.
［5］楼晓明, 官旭晖, 曾令峰, 等. 孔底间隔装药孔壁冲击压力特性［J］. 爆炸与冲击, 2023, 43(6): 065201.
LOU X M, GUAN X H, ZENG L F, et al. Characteristics of the impact pressure of the hole wall by interval charge at the hole bottom ［J］. Explosion and Shock Waves, 2023, 43(6): 065201.
［6］杨国梁，杨仁树，姜琳琳. 轴向间隔装药爆破沿炮孔的压力分布［J］. 爆炸与冲击, 2012, 32(6): 653-657.
YANG G L, YANG R S, JIANG L L. Pressure distribution along borehole with axial air-deck charge blasting ［J］. Explosion and Shock Waves, 2012, 32(6): 653-657.
［7］张馨, 孙金山, 张湘平, 等. 钻孔爆破炮孔孔壁压力计算模型［J］. 爆破, 2021, 38(3): 1-5.
ZHANG X, SUN J S, ZHANG X P, et al. Calculation model of blasthole pressure ［J］. Blasting, 2021, 38(3): 1-5.
［8］叶志伟, 陈明, 魏东, 等. 不耦合装药爆破孔壁压力峰值的实验研究［J］. 爆炸与冲击, 2021, 41(5): 055201.
YE Z W, CHEN M, WEI D, et al. Experimental study on the peak pressure of borehole wall in decoupling charge blasting ［J］. Explosion and Shock Waves, 2021, 41(5): 055201.
［9］叶志伟, 陈明, 李桐, 等. 小不耦合系数装药爆破孔壁压力峰值计算方法［J］. 爆炸与冲击, 2021, 41(6): 064901.
YE Z W, CHEN M, LI T, et al. A calculation method of the peak pressure on borehole wall for low decoupling coefficient charge blasting ［J］. Explosion and Shock Waves, 2021, 41(6): 064901.
［10］谢烽, 江雅勤, 余德运, 等. 钙结砾岩空气间隔装药爆破试验及应用［J］. 爆破, 2020, 37(4): 63-68.
XIE F, JIANG Y Q, YU D Y, et al. Test and application of calcium conglomerate air-decked charge blasting ［J］. Blasting, 2020, 37(4): 63-68.
［11］刘庆, 康强, 赵明生. 采石场空气间隔装药数值模拟及应用［J］. 爆破, 2013, 30(3): 65-69.
LIU Q, KANG Q, ZHAO M S. Numerical simulation and application of air deck charging in quarry ［J］. Blasting, 2013, 30(3): 65-69.
［12］李顺波, 李泽华, 李宏伟，等. 顶部空气间隔装药对岩石爆破块度影响的试验研究［J］. 爆破器材, 2020, 49(6): 61-64.
LI S B, LI Z H, LI H W, et al. Experimental study on the influence of top air-deck charge on rock fragmentation in blasting ［J］. Explosive Materials, 2020, 49(6): 61-64.
［13］张晓平, 马建军, 刘令. 露天深孔空气间隔装药爆破的数值模拟研究［J］. 科学技术与工程, 2020, 20(33): 13599-13605.
ZHANG X P, MA J J, LIU L. Numerical simulation of open-air deep-hole air-decking charge blasting ［J］. Science Technology and Engineering, 2020, 20(33): 13599-13605.
［14］张袁娟, 赵强, 李星. 台阶爆破间隔装药最佳间隔位置确定方法［J］. 煤矿安全, 2016, 47(8): 230-232, 236.
ZHANG Y J, ZHAO Q, LI X. Determination method for optimum spacing position of spaced loading of bench blasting ［J］. Safety in Coal Mines, 2016, 47(8): 230-232, 236.
［15］张迎吉, 周建敏, 徐文文, 等. 不同位置空气间隔装药爆破减振和破碎效果试验［J］. 工程爆破, 2015, 21(1): 15-19.
ZHANG Y J, ZHOU J M, XU W W, et al. Experiment on effect of vibration reduction and rock fragmentation for different positions airdecking charge blasting ［J］. Engineering Blasting, 2015, 21(1): 15-19.
［16］卢文波. 岩石爆破中应力波的传播及其效应研究［D］. 武汉: 武汉水利电力大学, 1994.
［17］戴俊. 岩石动力学特性与爆破理论［M］. 北京: 冶金工业出版社, 2002.
DAI J. Dynamic behaviors and blasting theory of rock ［M］. Beijing: Metallurgical Industry Press, 2002.
［18］戴俊.柱状装药爆破的岩石压碎圈与裂隙圈计算［J］. 辽宁工程技术大学学报(自然科学版), 2001, 20(2): 144-147.
DAI J. Calculation of radii of the broken and cracked areas in rock by a long charge explosion ［J］. Journal of Liaoning Technical University (Natural Science), 2001, 20(2): 144-147.
［19］杨仁树, 肖成龙, 李永亮, 等. 不耦合偏心装药结构爆破损伤破坏的分形研究［J］. 振动与冲击, 2020, 39(12): 129-134.
YANG R S, XIAO C L, LING Y L, et al. A fractal study on blasting damage of an eccentric decouple charge structure ［J］. Journal of Vibration and Shock, 2020, 39(12): 129-134.
［20］杨仁树, 许鹏. 爆炸作用下介质损伤破坏的分形研究［J］. 煤炭学报, 2017, 42(12): 3065-3071.
YANG R S, XU P. Fractal study of media damage under blasting loading ［J］. Journal of China Coal Society, 2017, 42(12): 3065-3071.

备注/Memo

备注/Memo:
收稿日期：2023-01-21
基金项目：国家自然科学基金（51974007，51874002）
第一作者：林继凯（1986－），男，硕士，高级工程师，主要从事采矿工程的研究。E-mail：516463703@qq.com
通信作者：刘增辉（1975－），男，博士，教授，主要从事采矿工程的研究。E-mail：953471093@qq.com
更新日期/Last Update: 2023-12-04